ISS MER Daily Report 17 Mar 2001
ISS MER Daily Report | ||
Date: 3/17/01 | STS 98/ISS 5A.1 | GMT: 75:12:00 To GMT: 076:12:00 (12 a.m. 3-16-01 to 12:00 a.m. 3-17-01) |
OVERALL SYSTEM STATUS: ISS/Shuttle docked, ISS in control of attitude: | ||
- FGB : SD 1,3,4 and 5 powered off do to telemetry problems, all other SD on, Dew Point 52.8 deg. F (55.2 deg. F); EPS: Nominal; Battery 6 offline in deep discharge (nominal). FGB Komparus failed and deactivated. C&DH: FGB-2 MDM on, FGB-1 MDM off.
- SM Elektron is off. Vozdukh is on. BMP status is on. CKB1 is on and in condensing mode; CKB2 is failed sensor and is non operational, powered off. Rapid depress response is off, Low-pressure warning is enabled. Dew Point 52.5 deg. F (52.8 deg. F). EPS: Nominal; Batteries in incomplete charge mode. SM ARCUs 22 online. SMTC: SMTC-1, 2 are operating in the redundant set. SMTC-3 was reported out of the set at GMT:2001/066:14:00 GMT; SMCC: SMCC 1, 2, and 3 are all operating in the redundant set. SMCC-1 is primary.
- NODE1 ACS: Pressure limiting inhibited. Both Node 1 PPRV’s are not capped-MOD uncapped during PMA3 depress. IMV Fans: Node 1 Aft Port operating; all others off. IMV Valves: Node 1 aft port open and enabled; Aft Stbd closed and enabled; Port-fwd inhibited, Deck Aft is open and enabled; Deck Fwd is closed and enabled; Stbd both inhibited; Fwd both enabled and open. FDS: SD-1 enabled, SD-2 Smoke detector off due to RPC Trip. THC: Node 1 cabin fan is operating; RAMV (N1 side) is enabled in 90% cool for MPLM. C&DH: N1-2 MDM is primary, N1-1MDM is secondary
- LAB PCA: Lab PCA on and monitoring. Positive Pressure relief is enabled VRCV and VRIV are closed. IMV Vlv/Fans: aft IMV valves are enabled and open. Aft port IMV fan is on. Fwd Stbd IMV valve is enabled and open. Fwd Stbd IMV fan is on. FDS: Smoke detectors LAB1PD1, LAB1SD5, & LAB1D6 on. CCAA: LAB1P6 full up. CDRA: Fail state. TCCSS: Full up state. MCA: Operational and providing US lab and Node and MPLM samples. Vacuum System: VRS & VES are closed. All VES RIVs are closed. Water Venting: Idle state. Condensation tank quantity indicates 70.42 lbm (65.49 lbm). Condensate "T" is not installed. Cabin Pressure: 14.65 psia (14.66), Cabin Temp 76.1 deg. F. (75.8 deg. F), ppCO2 is 3.9 mmHg (3.1 mmHg), ppO2 is 158.7 mmHg (160.6mmHg). EPS: is nominal., RWS-Lab UOP 7 had GFCI trip during checkout. RPCM N13B-A RPCM 16 (Node SD2) experienced an over current trip; TCS: ATCS &PTCS are nominal;. ITCS: LT and MT in dual loop mode. The low temperature 3-way mixing valve is in full flow through, with outlet temperature of 44.8 deg. F (7.1 deg. C). The moderate temperature 3-way mixing valve is controlling to outlet temperature to 63.3 deg. F (17.4 deg. C.) Rack temperatures are nominal. C&T: Ecomm is powered off. S-band: configured for HDR; Audio Subsystem: configured for IAC2 and operations are nominal. AUAI2S, RAIU 1 have PBIT Faults. Video System: Operational. CBCS: Video cabin from ISS to PMA2 and shuttle in check out testing. C&DH: C&C MDMs: 1 is primary, 2 is backup, 3 is in standby. INT MDM: INT-2 is operating, INT-1 is off. GNC MDMS: GNC-1 primary, GNC-2 backup; LA MDMs: LA-1, LA-2, and LA-3 operating.
- Crew Systems: TVIS is operational with foot plate installed. IRED only one canister operational, no fix til 6A.
- MPLM : Temperature is 76.8 deg. F (78.1 deg. F). ppCO2 3.3 mmHg. (MPLM shell heaters have been turned off). Overhead Aft IMV enabled and open; Overhead Fwd IMV valve closed; cabin fan on, smoke detector on; PPRA 1, 2, and 3 are closed. MDM Operating.
- P6 : Both PCUs in discharge mode. PVCU MDM 2B is prime/4B Backup. BGAs in Auto Track Mode. EETCS Loops A&B running on A pumps; FCV enabled; PFCS line heater 1&2 for loop B and B operational. RPCMs: N13B-A & N14B-C have health flags. PMCU: PMCU-1 MDM primary, MPCU-2 off.
- GNC : ISS is currently flying in TEA ISS/CMG TA in control of Mated stack, Beta Angle —15.9 degrees and mag decreasing. Avg. altitude is 211.7 x 203 nm; 392.18 x 376.02 km (200×210 nm; 370 x 389 km). S&M subsystems quiescent and operable.
Previously Reported Status
- Activation of RWS
- MPLM transfer activities
- Trouble shooting of CBCS
- Node 1 8A & 9A heaters forced to enable. 2nd occurrence within 24 hours.
- C&C #3 MDM successfully loaded and reinitialized.
Last 24 Hours Status
SIGNIFICANT EVENTS SCHEDULED FOR THE NEXT 24 HOURS:
Open Chits | ||||
Number (ISS) | Response Due (GMT) | Summary of Progress (OPEN ISSMER CHITS — LATE ISSMER CHITS — NON ISSMER CHITS)Chits without further MER Input required Chits that require MER Manager Action! | ||
The following chits are all in Mission STS-098_5A | ||||
ISS0009 | 2001/037:00:00 | MOD to IPRUSSIA, ISSMER — "5A Increment Full C&W Checkout Procedure" | 3/9 — MER-M is not ready to close this CHIT — DO NOT CLOSE | |
ISS0126 | 2001/046:18:00 | ISSMER to IPRUSSIA,MOD — "Russian Depress Sensor Status" | 2/26 — MOD response is in, need response from Russians | |
ISS0199 | 2001/060:17:04 | MOD to ISSMER — "S-bd Forward Link Audio Demux Activity" | 3/9 — Expect info from HB and KSC today or tomorrow to close early next week. C&T Test scheduled for ISL on 3/22 to characterize data stream corruption of MRELP | |
ISS0204 | 2001/060:00:00 | MOD to ISSMER — "Add NCS Loadshed Table 5 to Recon" | 3/10 — ISSMER response provided. | |
ISS0206 | 2001/088:15:00 | ISSMER to IPRUSSIA — "SMCC lane drop on GMT day 0505" | ||
ISS0207 | 2001/068:15:00 Post 5A.1- 80 | ISSMER to MOD — "Node 1 MDM CPU utilization dump requests" | C&DH gave Odin extension to GMT day 80 | |
ISS0211 | 2001/061:20:00 Post-5A.1 | MOD to ISSMER — "LA 1,3 LLA 11 Channel Anomalies" | 3/10 — HSV says data will not be available until post-5A.1. C&DH has concurrence from ODIN that this is OK. | |
TI0107 | ??? | ISSMER to ??? — Loss of S-Band Forward Audio Detection and Recovery" | 3/10 — C&T still working this. When ready to open, transfer to a 5A.1 chit. | |
TI0249 | 2001/???? | ISSMER to IMC, MOD, IPRUSSIA – "The Use of L200 Foam for Insulation Used around the SM Air Conditioner" | 3/9 — Want to add to 5A.1 Increment Ops job jar. HOLD Opening until after 5A.1 Mission. Should also transfer to 5A.1 Database. | |
The following chits are all in Mission STS-102_5A.1 | ||||
ISS0011 | 2001/066:12:00 | ISSMER to IPRUSSIA — "Request for SMCC Lane Change Information" | 3/16 — Russian Response provided — C&DH reviewing. | |
ISS0035 | 2001/071:20:30 | IMC to IPRUSSIA, ISSMER, MOD — "REQUIREMENTS: Updates to Stage 5A.1 Priorities" | ISS MER Response Provided | |
ISS0043 | 2001/071/23:00 | MOD to ISSMER — "Mass Properties Information for RSC-E Assembly & Config" | MER Response Complete | |
ISS0076 | 2001/073:16:00 | MOD to ISSMER — "S-Band RFG Antenna Self Test Failure" | MER Response Complete | |
ISS0088 | 2001/074:16:00 | IMC to CSR, ISSMER, MER, MOD — "5A.1 Transfer (MPLM): FD8, US Manifest/Transfer List" | MER Response Complete | |
ISS0090 | 2001/074:21:00 | IMC to ISSMER, CSR, MOD — "Requirements: Request for MACE II data download to PCMCIA" | MER Response Complete | |
ISS0091 | 2001/075:17:34 | IPRUSSIA to MOD — "S-Band timeline request" | ||
ISS0092 | 2001/074:08:00 | ISSMER to MOD — "Lab Condensate Venting Video Coordination" | ||
ISS0096 | 2001/075:18:00 | ISSMER to MOD — "Label SWIS Network Control Unit (NCU)" | 3/16 — Waiting for OSO concurrence | |
ISS0100 | 2001/075:06:00 | IMC to IPRUSSIA, ISSMER, MOD, CSR — "5A.1 ADD Docked Day to Flight for MPLM Stowage" | 3/16 — Chit asks for analysis, but specifies analysis deadlines that are after the chit’s deadline. | |
ISS0101 | 2001/076:02:00 | ISSMER to IMC, MOD, CSR, MER — "Return of Dessicant Bags" | 3/16 — Chit opened, awaiting responses | |
ISS0103 | 2001/076:16:00 | IMC to CSR, ISSMER, MER, MOD — "5A.1 Transfer (Shuttle Middeck): FD8, US Manifest/Transfer List" | 3/16 — MER Response Complete | |
ISS0104 | 2001/076:12:00 | ISSMER to MOD — "Antenna Calibration to avoid SSU radiation" | ||
ISS0105 | 2001/077:14:39 | IPRUSSIA to MOD — "Onboard Control Events Protocol & Data on C&W signals appearance in USOS" | ||
ISS0106 | 2001/077:00:00 | ISSMER to MOD — "Request BDTs to verify health of SSU 2B" | ||
ISS0108 | 2001/076:02:00 | IMC to IPRUSSIA, ISSMER, MER, MOD — "5A.1 Transfer: FD9, Russian Manifest/Transfer List" | L&M working | |
ISS109 | 2001/077:00:00 | MOD to ISSMER — "Failed Dzus fastener on LAB1DO-02 Panel" | 3/16 — S&M working | |
TI0115 | 2001/075:20:00 | IMC to CSR, ISSMER, MER, MOD — "5A.1 Transfer: FD9, RUSSIAN Manifest/Transfer List" | ||
TI0127 | 2001/076:00:18 | ISSMER to IMC,MOD — "TVIS Imagery" | 3/16 — Waiting for Safety | |
Closed Chits | ||
Number (ISS) | Response Due (GMT) | Summary of Progress |
The following chits are all in Mission STS-098_5A | ||
ISS0210 | 2001/060:20:00 | IPRUSSIA to MOD — "S-Band Timeline Request" |
The following chits are all in Mission STS-102_5A1 | ||
ISS0025 | 2001/068:23:00 | ISSMER to MOD — "Recently Released Station Program Notes" |
ISS0066 | 2001/074:12:00 | ISSMER to MOD — "MSD DDC Defect Data Dump Request Modification" |
ISS0070 | 2001/073:12:00 | MOD to ISSMER — "ISS Condensate Venting Attitude Constraints" |
STS0073 | 2001/074:15:42 | CSR to IMC, ISSMER, MER, MOD — "Transfer LiOH Cartidges from MPLM to Shuttle |
ISS0075 | 2001/073:01:15 | MOD to ISSMER — "Internal Audio Controller (IAC) 1 Transition Anomaly" |
ISS0077 | 2001/073:16:00 | IMC to CSR, ISSMER, MER, MOD — "5A.1 Transfer (Shuttle Middeck): FD7, US Manifest/Transfer List" |
ISS0078 | 2001/073:16:00 | IMC to CSR, ISSMER, MER, MOD — "5A.1 Transfer (Shuttle MPLM): FD7, US Manifest/Transfer List" |
STS0085 | MOD to MER | |
ISS0087 | 2001/074:19:00 | IMC to ISSMER, et.al. — "5A1 Transfer (Shuttle Middeck): FD8, US Manifest / Transfer List" |
ISS0095 | 2001/073:05:26 | IMC to ISSMER, et.al., -"5A.1 Middeck Return Transfer: Add the following items to the middeck for return" |
ISS0102 | 2001/075:15:45 | IMC to ISSMER, MOD — "RSP Bag Swap" |
ISS0097 | 2001/075:15:00 | ISSMER to IMC, MOD, IPRUSSIA — "Return of CWC S/N 5066 on 5A.1" |
ISS0107 | 2001/079:14:06 | ISSMER to IMC, MOD — "TVIS Imagery" – withdrawn |
Open Items for Investigation (IFIs) | ||
Number | Title/Summary | Status |
170 | PCU Tubes never reached temp when heaters active | 3/6 — Final solution in work. PRACA? |
210 | FPP Failure to Acquire Data | 3/6 — Need data from Eliason |
218 | EVA Tool does not fit TCS Nonpropulsive Vent bolt heat | 3/8 — Need to have details of EVA bolt resolution at KSC. Ready to close? |
227 | Burnt wires on veloergometer control box | 3/6 — Need data filled in by EV&CS |
229 | HRDL MSD Inaccessible | 3/6 — Need data filled in by C&DH |
230 | Node 1 PMA Duct Missing Parts | 3/16 — Need to find out from crew how duct was reconfigured following the Soyuz relocation. Parts are on orbit. Has the crew found them yet? |
235 | Treadmill Slats Broken | 3/16 — Need data filled in by EV&CS Have FIAR. Can close when IFI data filled in. |
241 | Station Vibration During TVIS Exercise | 3/16 — Need data filled in by S&M or EV&CS? Waiting for IWIS data. |
244 | Periodic Annunciation of S-Band XPDR Non-critical Failure advisories | 3/8 — Need Software PR. Needs to go to ASCB to get approval to write PR. C&T and C&DH working this. |
245 | S-Band BSP Loss of Forward link Audio Channel RELP Sync | 3/7 — Close to S/W PR 2124? C&T confirming with MEIT data that this is the same problem. |
247 | Hitch Pin on WIF adapter Separated from Lanyard | 3/16 — Have FIAR. EV&CS providing additional data for closure. |
248 | Audio Subsystem AUAI2S PBIT Indication | 3/7 — Hardware is working. C&T needs additional data dumps to diagnose problem. Check PBIT chit. |
249 | C&C-2 MDM Switched to Diagnostic from Primary | 3/8 — PPL uploaded. Still in work by ASCB? |
253 | SM KURS-P "Not Normal" Indication | SM Nadir Port Set 1 Self test failed twice. MCC-M plans to test on aft port to try isolate problem to the cable. SM Aft port test passed 3/16 — VI/Jack Bacon working this. Need to fill in IFI data. |
254 | BGA Observed vs Commanded Position (part 3) | 3/16 — Non problem, but need NASA S/S Manager concurrence. Need Flt Rule CR to document reqt to lock BGAs? |
255 | OCA Intermittent Operation | 3/7 – Need data and plan filled in by C&T |
259 | Echo on S-Band (Ground) | 3/8 — Troubleshooting procedure uplinked to crew (OCA 1652). Troubleshooting planned post5A.1. |
260 | CCS-2 MSD Year incorrect for Filename : LDF.txt | 3/7 – Need data filled in (from Funny Database?) by C&DH |
261 | S-BAND Gimbal Temperatures | 3/16 — Have PR20449. Ready to close? |
266 | N1-2 MDM EEPROM Checksum Error | 3/16 — MER C&DH working issue. Need SW PR. |
270 | 4B BGA Latch #2 Failure to engage | |
273 | 4B BGA Motor Current Trip | |
276 | Circles on Nadir CBM flange photographed | |
277 | Center line Berthing system unusable | |
278 | Internal Audio Controller (IAC) #1 Failover to IAC#2 | |
280 | N1N/MPLM Vestibule Closeout | 3/16 — Have PRACA. Waiting for crew to measure vestibule. |
281 | DDCU LA3B Output Voltage Bias higher than expected with Converter off | |
283 | S Band RFG Bit Summary | |
284 | MPLM RPC-11 Output Voltage above expected value when off. | |
285 | Node 1 8A Heater Forced to "Enable to Operate" | |
287 | Rack K-Bar Fit Problems | |
288 | UOP Trip During RWS Activation | |
289 | N1-3B-A RPC 16 Overcurrent Trip | |
290 | Lab Port water vent heaters did not achieve expected temperature. | |
291 | S Band Radiation of STBD SSU | |
292 | PCS Log Download Failure | |
293 | Lab Condensate Tank Leak fail indication | |
294 | Loss of PFR Attachment Device (PAD) | EV&CS will work this week of 3/19 |
295 | PMA3 Connector P601 Unable to throw bail on stowage receptacle | EV&CS will enter data and complete week of 3/19 |
296 | SM Gas Mask has 13 mm tear | ECLSS is working |
Closed Items for Investigation (IFIs) | |
Number | Title/Summary |
282 | MTSAS Active Capture Latch Turn Count |
264 | RPC Tripped during LTA Activation |
265 | DZUS Fastener on Lab Panel 1S7_03 |
271 | BGA Transition to Blind Mode Unexpectedly |
275 | P608 Dust Cap Cover |
286 | Node 1 3A Heater 3A & 8A Command Status Wrong |
274 | J603 O-Ring |
198 | SSC Network not Functioning |
209 | OCA Headset Cable Failure |
251 | SKV 2 Shutdown Due to Oil Pressure Sensor |
252 | EEATCS Loop A Radiator Return Temperature Spikes |
257 | Unexpected momentum/attitude disturbances |
262 | IRED Scraping |
279 | MPLM ELPS Current |
263 | Seat Track Fit Problem |
Action Items | Status |
